• Phone number
    0047-906-900-11

  • Email Address
    post@mietitura.no

Test reports and references

Please note that reports in bold are available to read (fully-translated in English and Russian). Those which are not highlighted are currently being translated.

On mobile devices, you may swipe across the table to view the rest of the columns.

Date, Year Location Nature of the test object The result of applying FORUM Type of test
2016 Kuban State Agrarian University Full-scale tests - MTZ-82 and 122 Antifriction and antiwear additive FORUM TU 0257-008-02698l92-2002 to engine oils, gearboxes and aggregates is an oil suspension of modified low molecular weight ultradisperse polytetrafluoroethylene (UPTFE). Additive FORUM improves lubricating, thermo-oxidative, anticorrosive properties of the oil. Provides a reduction in the time to take the load, reduce the contamination of engine parts during operation.

English report (PDF)
Russian report (PDF)
Engine oils, gearboxes
2016 Krasnodar region, Novokubansk, FGBU " Kuban IIA " Authentication and examination of the results obtained in the Institute of the Russian Defense Ministry on the state standards, for use in automotive engineering Anti-friction anti-wear additive to oils and lubricants FORUM has withstood the full range of tests on internal combustion engines, transmission units and bearings in accordance with GOST in leading Russian test and chemical centers, as well as at car manufacturers and has shown the following efficiency: Engine increases to 6% with a simultaneous reduction in fuel consumption to 10%; - wear of gears falls 52 times; - Mineral oil retains its operational properties 2-4 times longer; - the oil consumption is reduced by half; - Carbon formation decreases by half; - wear of the cylinder-piston group is reduced by 2-3 times, - friction in oil decreases by 17%, without oil - by 100 times; - service life of bearings and drives is increased by two or three times; - the noise of the mechanisms is reduced by 2-7 dB. On worn engines, the effect of the FORUM additive increases many times. Based on the results of the tests, a joint decision was made by the Russian Defense Ministry Center for Strategic Research, the Russian Defense Ministry's Defense Ministry, and the KAMAZ Scientific and Technical Center on the admission of an antifriction anti-wear additive to FORUM® oils for use in engines and transmission units of the KAMAZ ABhS, supplied for federal (state) needs. An instruction has been developed and agreed upon that determines the order of application in the military automotive engineering of the additive to FORUM-B oils (see annex)

English report (PDF)
Russian report (PDF)
Combustion engines, transmission units and bearings
2016 Vladivostok, the Pacific Fleet of the Russian Navy Field tests of dry lubricant Forum introduced in the paint on the RCA Navy During this inspection, it was established that the hull of the ship had no sea crust and the rate of paint wear did not exceed established parameters. Pacific Navy submitted our proposals to the General Navy Command - to move an Amendment into the used technology of the underwater ships’ parts painting, taking into account, the properties of the powder FORUM, and to include it into the nomenclature of Navy ships supply.

English report (PDF)
Russian report (PDF)
Ship Hull Paint
2015 Krasnodar region, Ust-Labinsk, Agroholding "Kuban" Full-scale tests on the tractor "Bueller" Conclusion 1 p.Application of the FORUM additive on the engine Buller allows to save more than 26 liters of oil during operation for 250 m / h. It is recommend the use of the additive FORUM to oils on the entire vehicle fleet of JSC Agroobedinenie Kuban due to the increased profitability of its operation..,

English report
Russian report
Test reports English (PDF)
Test reports Russian (PDF)
Engine oil
2014 Naberezhnye Chelny, ZAO "PTFK" vehicle electrical plant " Tests Forum grease in the bearings In view of the fact that vibration and temperature indicators with "FORUM" lubricant are better in comparison with Lithol, it is recommended to use "FORUM" lubricant on warranty engines.

English report (PDF)
Russian report (PDF)
Engine/transmission
2013 Mezhdurechensk, ZAO HC "Tatelektromash" Tests Forum grease in the bearings To increase service life of bearings it is recomended to change grease Liton 24 to grease FORUM on products of Closed Joint-stock Company ZTEO operating under limited company TATELECTROMASH Siberia.

English report (PDF)
Russian report (PDF)
Grease
2013 Slovakia, Nitra Field tests on buses Bus#1 registration number 485DU, after application of FORUM, reduction in fuel consumpsion 12.3% for 100km journey.

Bus#2 Registration number 486DU, after application of FORUM in engine, reduction in fuel consumpsion 11.04% for 100km journey.

English report (PDF)
Russian report (PDF)
Engine oil
2012 Shiprepair Yard "Pregol", Kaliningrad The introduction of full-scale tests of dry lubricant Forum in the ship's paint (MES boat) July 29,2012 after cutter launching as a result of sea trials (Weather conditions: wind 5 m / s, sea 1 point), the speed of the ship compare with previous indications increased from 48 to 50.5 knots during four hours of speed tests.

In November 2012, when examined by divers, algae fouling was not observed. There are small shells attached on the stern side of the hull, which when you touch them with the diver's glove leave the paint freely, but a trace there remains. When the boat moves at high speed, the shells are washed off the bottom of the boat, but traces remain on the bottom surface.

There are our wishes to increase the concentration of nanostructures (FORUM in the paint by three or five times.

English report
Russian report
Ship Hull Paint
2006 Moscow, Naberezhnye Chelny, Federal State Unitary Enterprise "25 State Research Institute Minobrony Russia." FSUE "21 SRIE Defense Ministry Russia." OJSC "KAMAZ". The joint solution CCRFG (Central Control of Rocket Fuel and Gas, Russian Ministry of Defense, MAAD (Main Automobile Armored Directorate of the Ministry of Defense), Russia, STC OJSC "KAMAZ". Antifriction antiwear additive for oils FORUM is approved for use in engines and transmission units ABSH "KAMAZ" supplied to federal (public) use.

English report (PDF)
Russian report (PDF)
Engine, transmission units
2004 Moscow, Federal State Unitary Enterprise 21 NIII AT Defense Ministry. Bench tests KAMAZ-740 engine at low temperatures. Time after startup until stable operation was reduced by 2.5 times. Oil life increased 3 times (base number). The wear of the cylinder-piston group decreased by 30%. The wear of crankshaft and liners decreased by 50%.

English report (PDF)
Russian report (PDF)
Engine oil
2004 Naberezhnye Chelny, OJSC "KAMAZ". Engine test bench KAMAZ-7403.10, drive axles and gearboxes (mod. 152). Tests engines and transmission units under emergency loss of lubricant. Engine withstood 1000 hours of reliability testing in the trouble-free mode, the aging rate (response rate) of engine oil decreased by twice. During operation of the engine without engine oil, only the wear of the crank shaft, connecting rod bushes and bearings. Without treatment with FORUM additive, the rotation of the main and connecting-rod bushes, the scoring of the connecting rods, the thrust bearing half rings, the turbocharger bearing, the cracks of the abutments are recoded..

English report (PDF)
Russian report (PDF)
Engine oil, bearings, drives
2004 Vladivostok, JSC "Port fleet". Full-scale testing of marine engines 3D12AS (GOST 12 ChSP 15/18). Oil consumption decreased by 40%, disappeared metallic noise, reduced overall vibration level, increased compression, engines start became easier. The engines became softer.

English report (PDF)
Russian report (PDF)
Engine oil
2003 Vladivostok LLC "Spetsavtohozyaystvo M". Full-scale car test engine GAZ 3307 Extreme engine operation more than a day with a deficiency of oil in the system. The engine kept its performance. Disassembly of the engine shown there are no burrs on the surface of the crankshaft.

English report (PDF)
Russian report (PDF)
Car Engine
2003 Vladivostok, JSC "Festehservis". Full-scale testing of diesel generator 8CHN 24/34 The method of measuring the density of vibration and density of CPG (Cylinder-piston group) found that after 400 hours of operation, the overall level of vibration has decreased and density of CPG increased to 24%.

English report (PDF)
Russian report (PDF)
Diesel generator, Engine oil
2003 Vladivostok, OJSC "FESCO". Field tests of auxiliary diesel-generators on the m / v A. Twardowski. The oil pressure increased by 0.2 kg / cm2, knocking in the area of the crank bearing stopped, the overall level of vibration decreased, the vibration level in the area of the drive gears decreased two times, the high-frequency vibration decreased, which indicates an improvement in the sliding quality of the mating parts..

English report (PDF)
Russian report (PDF)
Engine oil, transmission
2002 St. Petersburg, JSC "VNIItransmash". Bench tests of the engine and transmission oil. Significantly reduced engine wear. Gear wear is reduced by 52 times; in the "dry" condition friction, the service life of gears is substantially extended.

English report (PDF)
Russian report (PDF)
Engine and transmission oil
2002 Vladivostok, PNI them. SO Makarova. Field tests 6811 caliber gimp barrel 14.5 to the product of 2C-1. After 104 shots, a coating of polytetrafluoroethylene (FORUM) is preserved on the inner surface of the barrel. Which positively affects the corrosion resistance of the barrel surface and its "survivability".

English report (PDF)
Russian report (PDF)
Arms, Guns
2002 Ussuriysk, of "Spring". Full-scale tests on the 15 trucks SCANIA, 6 KAMAZ 2 MAZah. Reducing fuel consumption by 5-10% and oil 50%, decreased noise and increased stability of the engine, the car accelerates faster and power increased.

English report (PDF)
Russian report (PDF)
Engine oil, transmission
2001 Moscow, 25 Research Institute of the Russian Defense Ministry. Bench tests of lubricants with the addition of the Forum. The presence of FORUM additive in the composition of any lubricant improves its antiwear and extreme pressure properties to a greater or lesser degree . The effectiveness of anti-wear actions of FORUM surpasses all traditional antifrictional additives.

English report (PDF)
Russian report (PDF)
Laboratory Analysis of FORUM
2001 Vladivostok, Institute of Chemistry FEB RAS. Laboratory tests of coatings. The contact angle of wetting with 25% sulfuric acid is increased to 20-40 degrees, the chemical resistance of the coating is increased ten times.

English report (PDF)
Russian report (PDF)
Analysis of FORUM as Paint Additive
2001 Vladivostok LLC "Tehnohim". Field tests of automatic gearbox (automatic transmission) car MMC Galant. After 30 thousand km run, the protective antifriction layer FORUM is left on the surface of friction pairs - the sliding bearing (Babbitt) - steel shaft. Wear is absent. The filter element retains good throughput.

English report (PDF)
Russian report (PDF)
Gearbox/transmission
2000 Vladivostok, Primorye Regional Federation of water-motor sports. Full-scale tests "Vikhr-30" outboard. Maximum speed increased from 4500 to 5200, decreased motor noise, the speed on track increased without changing the settings. Fuel consumpsion decreased by 14%. At considerable overheating of the engine did not show any signs of scoring and wear of bearings. Coating Forum was not damaged.

English report (PDF)
Russian report (PDF)
Water motor sport boats, Engine oil
2000 Moscow, Federation of Aircraft Modeling Sport of Russia. Full-scale testing of a two-stroke engine OS-MAX 46 FX and four-YS-14OL. FORUM powder coating on the painted surfaces of the aircraft. On OS-MAX 46 FX increased compression, the engine began to run in hot state. On YS-14OL at maximum speed, noise decreased by 3 dB. On painted surfaces improved gloss, water repellency and aerodynamics.

English report (PDF)
Russian report (PDF)
Engine Oil , paint additive
2000 St. Petersburg, Central Research Institute "Prometey". Laboratory tests on the friction machine Mi-1 antifriction carbon plastics. Modified by FORUM carbon plastics have strength at the level of initial carbon fiber reinforced plastics, wear resistance is increased by 15-20%.

English report (PDF)
Russian report (PDF)
Engine Oil
2000 Vladivostok, in / h 30924. Full-scale tests, SAG (122mm). Shooting accuracy increased to 36%, projectile speed increased by 3%.

English report (PDF)
Russian report (PDF)
Gun
1999 Vladivostok, LLC "Sea Fishing Company" BMR "Bay of Peter." Full-scale tests. Ch. motor 8 NVD 48 A2U, GTN 50 PDH. EDC (electronic diesel control) power increases, ash oil decreases, easier starting, no blue smoke during cold start-up. Significantly reduced fuel consumption.

English report (PDF)
Russian report (PDF)
Engine oil/motor
1999 Khabarovsk, ZAO HZMK ". "Hirota" full-scale tests of hydraulic system lentopilnogo machine. Decreased time for heating the hydraulic oil at low negative temperatures, reduced oil leakage, increased operation smoothness of hydraulic rod mechanisms.

English report (PDF)
Russian report (PDF)
Engine oil/hydraulic system
1999 Vladivostok, LLC "Sea Fishing Company" CTP "Vidanovo". Full-scale tests. Ch. motor 6 NVD 48 A2U, EDC 6CHN 18/22, 32 HHP PDH. On the main engine bearing, there are no signs of destruction expressed prior to treatment. The life time of the oil has doubled, and the consumption of oil for "burnout" has decreased by two times. Disappeared gray smoke during cold start. Increased engine power.

English report (PDF)
Russian report (PDF)
Ship Engine oil
1998 Japan, JSN. Full-scale tests on the track Niigata - Tokyo. Cars, lorries, with different types of engines and run period. In all cases, there is reduction in fuel consumption, on average 10%.

English report (PDF)
Russian report (PDF)
Car Engine oil
1998 Japan, HITEQ (test center Nissan). Bench tests Nissan Cefiro (gasoline engine) Nissan Terano (diesel engine). Nissan Cefiro, mileage 17 thousand Km, began to pick up speed, increased engine power, more smooth rolling is noted. Nissan Terano, mileage 48 thousand Km, power and throttle response increased significantly. Smoke decreased by 6%.

English report (PDF)
Russian report (PDF)
Car Engine oil
1998 Khabarovsk, HTEC-2. Field tests e. engine power of 230 kW. A decrease in the coefficient of friction, an increase in the rotational speed and vibration, reduction of vibration acceleration, which increases the durability and reliability of the bearing assemblies, as well as to reduce electric consumption. energy by reducing the friction coefficient.

English report (PDF)
Russian report (PDF)
Gears, drives
1997 Vladivostok, Ltd. "Shipping company Pavino" tanker "Pavino". Full-scale tests, auxiliary diesel generator. After treatment with additive FORUM, the oil consumption was reduced by 18-20 times, the critical load increased 2 times at which the engine was overheating, the engine power increased by 10%.

English report (PDF)
Russian report (PDF)
Ship Engine oil
1995 Samara, MSPATP-5. 5 "Ikarus" buses. An increase in the idling speed, a general decrease in noise, an improvement in engine stability have been noted. According to drivers, fuel consumption fell by 5%. A positive effect of the additive on the nature of the operation of air compressors having a lubrication system common with the engine was noted. In general, the additive "Forum" has a positive effect on the operation of diesel automobile engines.

English report (PDF)
Russian report (PDF)
Engine Oil
1995 Moscow, "Interdepartmental Commission for granting permits for the production and use of motor oils for automotive vehicles. The Commission, composed of representatives VNIINP, NATI, JARI, JSC "NAMI-CHEM", "ZIL" YAMZ, JSC "GAZ 25 Research Institute of Ministry of Defense of the Russian Federation, JSC" Moskvich "Company" producers of oils and additives. " Commission decision: Allow FORUM additive for use in engines and in the composition of oil, on which the tests were conducted.

English report (PDF)
Russian report (PDF)
Engine oil
1995 Moscow, JSC "Moskvich", UKER. Laboratory and road tests of 2141 models gearbox. A decrease in the noise level of the main gear at the main operating conditions is noted, the extreme pressure and anti-wear properties of the oil are increased. According to the test results, the additive "Forum" is allowed to be used in the transmission of the car "Moskvich 2141".

English report (PDF)
Russian report (PDF)
Gearbox
1994 Tomsk, Institute of Optics atmosphere RAS. Laboratory studies powder FORUM by light scattering on the powder in the gas phase. The maximum concentration of powder particles is in the range 0.5-0.6 microns in diameter.

English report (PDF)
Russian report (PDF)
Laboratory Analysis of FORUM
1994 Samara State Aerospace University Innovation Center to them. SP Queen. Bench tests on the engine VAZ-2106. The power increase by 2-6% and at the same time, reducing fuel consumption by 5-10%. When the filter element was opened, no particles of FORUM powder were found in it. With organoleptic oil control, it is established that its quality significantly exceeds the quality of the standard oil for a similar test duration.

English report (PDF)
Russian report (PDF)
Engine oil
1994 Moscow, in / h 74242. Bench tests on the single-cylinder engine. Increased in oil pressure (0.1 atm) at the inlet of the engine after a filter was noted, this suggests that the additive passes through the filter. A decrease in the friction losses of 1-3% has been observed.

English report (PDF)
Russian report (PDF)
Engine oil, bearings/drives
1994 Moscow AZLK. Bench tests of the engine of fashions. 331.17 car "Moskvich". Oil consumpsion to "burnout" decreased by 47%, lacquer and carbon formation decreased by 41%, the wear on the oil base number (alkaline number) decreased to 4 times, wear of engine parts decreased many times.

English report (PDF)
Russian report (PDF)
Engine Oil,
1994 Krasnoyarsk, NGO "Plasma". Laboratory studies of the dispersed phase FORUM by electron microscopy. FORUM powder consists of particle size: less than 1 micron 98.3%; from 1 to 1.42 micron 1.7%; for 98.3% particles: 86.5% particles consist of 0.12 to 0.59 micron .

English report (PDF)
Russian report (PDF)
Laboratory Analysis of FORUM
1994 Moscow, VNIIPTI AEC "Dynamo". Full-scale tests. Traction DC motor 213 DK V2. Residual engine life extended 2-3 times.

English report (PDF)
Russian report (PDF)
Engine oil
1994 Vladivostok, in / h 26874. Full-scale testing of the machine converter CAM. Increased service life of bearing units 3 times.

English report (PDF)
Russian report (PDF)
Bearings/drives
1993 China, Harbin Engineering University. Laboratory tests on the 4-ball friction machine. 17 % decrease in coefficient of friction after 25 minutes start of the test, 30% decrease in wear scar diameter ball through 2-hour testing period.

English report (PDF)
Russian report (PDF)
Gun
1993 Vladivostok, in / h 30926. Field tests RPKS-74 machine gun. Accuracy of automatic fire increased by 23%, the middle point of contact with 100 meters distance increased by 1 cm.

English report (PDF)
Russian report (PDF)
Gun
1993 Vladivostok, in / h 30926. Field tests of small arms SVD PKM, FCT. Patterning automatic firing when firing in the 100 m increased by 30% for SVD (Dragunov sniper rifle), 32% for PKM (Kalashnikov's Machinegun) , 62% for PKT (PK Tank), average hit point increased by 2 cm for SVD (Dragunov sniper rifle), 30 cm for the PKM (Kalashnikov's Machinegun), to 0 cm PKT (PK Tank).

English report (PDF)
Russian report (PDF)
Guns
1990 Moscow, Moscow Helicopter Plant. ML Mile. Bench tests in the tail gearbox izd.300. The noise level has decreased by 2 dB, improved surface state of the gears.

English report (PDF)
Russian report (PDF)
Gearbox
1990 Tyumen, NGOs "Technique and technology of oil production." Laboratory studies, installation of SMC-2. In the friction pair steel 40X - 40X steel wear decreased by 1.46 times. The friction pair MDO D16 - D16 MDO wear decreased by 4 times.

English report (PDF)
Russian report (PDF)
Bearings/drives

Industries We Serve

Automobiles/cars
Transport Industry
Ship Industry
Defence
Heavy Machines
Food Industry
Power Industry
Paint Industry
Wind turbine Industry
Copyright © Mietitura AS 2019. All rights reserved.